You are using an out of date browser. It may not display this or other websites correctly.
You should upgrade or use an alternative browser.
You should upgrade or use an alternative browser.
2007 renegade 600 ho sdi oil problem
- Thread starter bagman
- Start date
Looking for some help went to get sled ready for winter puddle of injector oil underneath sled ran fine last time i used it but now clean injector oil found in exhaust pipe the stinger part right out of manifold. Tried to do compression test could not pull over any thoughts?
Try DooTalk. Lots of SDI's around.
1flatlander2
Member
remove pipe drain oil. pull plugs and pull over. put some gas down there pull over. change plugs try to start.
Hydro-lock, either gas or oil. Pretty unlikely that it is oil but anything is possible. Maybe two things going on, oil line leak from tank to oil pump so you're seeing clean oil on the floor, not an uncommon problem. Needle & seat leaking filling cylinders with gas, running into the pipe and mixing with the deposits in the exhaust makes an oily looking mess.
There is no needle and seat on a fuel injection system. Not sure if there are crankcase drain plugs on 600 SDI??? Check front side of crankcase.
Sorry, I was thinking it was a standard HO.
T
Tracker
Guest
Looking for some help went to get sled ready for winter puddle of injector oil underneath sled ran fine last time i used it but now clean injector oil found in exhaust pipe the stinger part right out of manifold. Tried to do compression test could not pull over any thoughts?
I have a cat that did this also....redid motor and gaskets...same thing....it wont pull over since its loaded with oil....we pull plugs...pull over engine very easy like...some oil spews....then pull a tad harder until some comes out the pipe...then put in plugs....pull until one arm is like popeye....then she fires....smokes like he double tooth picks and then some...keep it running...make sure premium is in it and good amount cause if it dies you will then need 5 popeye volunteers and several cases of beer to fire up again....run until smoke goes way down....then you can ride it all season long...UNLESS....you let it sit again for a long spell like a month or more....it will be less than sitting all summer but there will be oil again...what causes it I could never find out....but sled still runs and does this...its a 1997 ZR 440...good luckski
PS...I think its a gravity thing and syphon effect on oil hose....I never tried storing with oil cap slightly loose