2007 Renegade 600SDI

[muss]

I bought a 2007 Renegade X 600 SDI Two years ago with 4000 miles, It now has 6300 miles on it. I have done all the general maintenance on it, cleaned the clutches, changed the slides,chain case oil kept it greased, belts.. Etc... It runs perfect and I have never had any issues other than a new voltage regulator and a new battery. I have two trips planned up north this year and I expect by the end of the year to have nearly 8000 miles on it. is there
Anything at this point with this many miles I should be doing other than the regular maintenance? Thanks

 

[doo_dr]

Keep up the good work

Keep up the good maintainance and ride. You want to keep an eye on your compression. As that drops off (getting clos to 100#'s) you have a higher chance of breaking a ring in a port, cracking a pistion skirt, etc... There is no specific service time line on sleds. How they are maintained and cared for determines their life. I had a 93' that had 8k non service issue miles on it and I didn't change the spark plugs for the first 3000 miles (2yrs). I checked and cleaned but did not change.

 

[indy_500]

Keep on doing what you're doing. It could probably use new clutch springs, but as long as you don't beat on it too bad, she should last till 10k

 

[muss]

Compression was at 130 last year and each side was the same. You reminded me I should check this again. I had someone else tell me I should get 10k on it as well, so it looks like the rest of this year and next year till I buy a new sled, or put some money in this one.

 

[russholio]

Keep an eye on the Y-pipe for cracks (may or may not happen, mine has almost 8K and no cracks yet), make sure the Y-pipe bolts stay tight, and keep an eye on the throttle body boots for cracks/delamination (I did have to replace mine).